混凝土搅拌机是用来运送建筑用混凝土的专用卡车，随着商品混凝土的产生而产生和发展的，它了商品混凝土从制备地点到浇注现场的运输问题，因此成为商品混凝土的理想运输工具。那么混凝土搅拌机装料运输期间要做的事情是怎样的呢？

Concrete mixer is a special truck used to transport construction concrete. With the emergence and development of commercial concrete, it solves the transportation problem of commercial concrete from the preparation site to the pouring site, so it has become an ideal transportation tool of commercial concrete. So what should be done during the loading and transportation of concrete mixer?

装料前应先将搅拌筒反转

Reverse the mixing drum before loading

车辆头班运行时尽可能先反转，因大多是露天停放，罐里可能会有积水、树叶等杂物，如不排出将影响混凝土质量。

During the first shift operation, the vehicle shall be reversed as far as possible, because most of them are parked in the open air, there may be ponding, leaves and other sundries in the tank, which will affect the concrete quality if not discharged.

装完料要记得冲洗进料斗

Remember to flush the feed hopper after loading

要不然装料时散落的小石子容易凝固在接料斗内外和溜槽上，影响使用和美观。

Otherwise, the small stones scattered during loading are easy to solidify inside and outside the receiving hopper and on the chute, affecting the use and beauty.

运输中拐弯的时候一定要慢

Be sure to turn slowly during transportation

搅拌车高，易侧翻！入弯之前提前减速减挡，尽量别拐弯的时候踩刹车。随时通过后视镜注意观察罐子是否在转，把转速尽量调慢，转速过高，车辆容易摆动。

The mixer truck has a high center of gravity and is easy to roll over! Decelerate and downshift in advance before turning, and try not to step on the brake when turning. Observe whether the can is rotating through the rearview mirror at any time. Slow down the speed as much as possible. If the speed is too high, the vehicle is easy to swing.

不好的路面低速挡通过

Low speed transmission on bad roads

遇到路面不平、坑坑洼洼地方用合适的低速挡通过，保证车子的动力充沛。遇到大坑，石头，钢筋，铁块尽量避让，尤其重车。

In case of uneven and potholes on the road, pass through with appropriate low gear to ensure sufficient power of the car. Try to avoid big pits, stones, steel bars and iron blocks, especially heavy vehicles.

上坡建议是提前减档

The suggestion for uphill is to downshift in advance

如果拉得满的话，注意起步要平缓，上坡更要注意，不能乱减挡，建议提前减挡。同时，建议加快罐子的转速，已免混凝土流出。

If it's full, pay attention to a gentle start and pay more attention when going uphill. Don't reduce gears randomly. It's recommended to reduce gears in advance. At the same time, it is suggested to speed up the rotation speed of the tank to prevent the concrete from flowing out.

下坡切勿重车空挡滑行

Do not slide with the loaded vehicle in neutral gear downhill

长时间行驶或者下坡前都要挂入合适档位行驶。切勿重车空挡滑行下坡。下坡拐弯时提前减速然后再减挡再减速，带挡刹车效果建议。

Shift into the appropriate gear before driving for a long time or going downhill. Do not slide down the slope with the loaded vehicle in neutral. When turning downhill, decelerate in advance, then reduce the gear, and then decelerate. It is recommended to stop the braking effect.

一定要注意限高问题

Be sure to pay attention to the height limit

工地路况复杂，要小心树木等，特别是要防止刮到电线。

The road conditions on the construction site are complex, so be careful of trees, especially to prevent scraping wires.

由于混凝土搅拌机的大规模使用，许多用户对一些日常的使用和维护了解不多，搅拌车的工作环境又比较恶劣，再加上用户不注意日常保养，就造成了一些不必要的故障和经济损失。在维护和修理方面必须遵照规定，执行“定期检测、强制维护、视情修理”的维护和修理制度。在这个大前提下，再结合混凝土搅拌机的实际情况，做好维护和修理。

Due to the large-scale use of concrete mixer, many users do not know much about some daily use and maintenance, and the working environment of mixer truck is relatively poor. In addition, users do not pay attention to daily maintenance, which has caused some unnecessary faults and economic losses. In terms of maintenance and repair, the maintenance and repair system of "regular inspection, compulsory maintenance and repair as appropriate" must be implemented in accordance with the regulations. On this premise, combined with the actual situation of the concrete mixer, do a good job in maintenance and repair.

混凝土搅拌机装料运输期间要做的事情相关内容便是这样了，您可以关注我们的网站www.zkhntjbc.com，了解更多的内容信息。

This is what should be done during the loading and transportation of concrete mixer. You can pay attention to our website www.zkhntjbc.com COM, learn more content information.