General usage of concrete mixer: after the mixer is powered on, start the main mixing motor through the start (stop) switch with protection function. When the equipment enters the normal operation condition, then add the substances to be mixed into the mixing plate of the mixer. At the same time, add a certain amount of water into the mixing plate through the water pump to mix together. After the materials are mixed evenly, Open the material door to discharge. After all the materials in the mixer are discharged, close the material door to complete a mixing cycle. The single-phase submersible pump is selected for water supply. The water supply is timed. After the water supply time is completed, the power will be cut off automatically and the water supply will be stopped. The whole water adding process is simple and easy to operate.

搅拌机通电往后，发动搅拌主电机的运用办法强力搅拌机进入正常作业状况后，再将不定型耐火材料参加到搅拌机的混合盘中，与此同时经过加水泵向混合盘内参加必定量的水一同搅拌，待物料搅拌均匀后，摆开料门，经排料溜槽进入小车内，小车可在作业导轨上恣意移动和停留，以满足主铁钩不同方位的加料需求，在搅拌机的物料悉数排净后，关闭料门，在作业时所有刮板与衬板之间应保持必定的空隙。供水选用单相潜水泵，计时供水，混凝土搅拌机价格供水完成后自动断电。

After the mixer is powered on, start the main mixing motor. After the strong mixer enters the normal operation condition, the amorphous refractory materials are added to the mixing plate of the mixer. At the same time, a certain amount of water is added to the mixing plate through the water pump to mix together. After the materials are mixed evenly, open the material door and enter the trolley through the discharge chute, The trolley can move and stay freely on the operation guide rail to meet the feeding needs of the main iron hook in different directions. After all the materials of the mixer are discharged, close the material door, and maintain a certain gap between all scrapers and lining plates during operation. The single-phase submersible pump is selected for water supply. The water supply is timed. The concrete mixer will automatically cut off the power after the water supply is completed.

搅拌机带叶片的轴在圆筒或槽中旋转，用以混合或揉和物质使成所需稠度的机器。搅拌机分为好多种，有强制式搅拌机、单卧轴搅拌机、双卧轴搅拌机等等。注意事项：搅拌机及自搅拌机动供料机，必须把里面清洗洁净，尤其是冬季，这样能延伸寿数。

A machine in which a bladed shaft rotates in a cylinder or groove to mix or knead substances to the desired consistency. There are many kinds of mixers, including forced mixer, single horizontal shaft mixer, double horizontal shaft mixer and so on. Precautions: the mixer and self mixing motor feeder must be cleaned, especially in winter, so as to extend the service life.

水泥混凝土搅拌机的用处就是机械化的拌制水泥混凝土，其种类较多，分类办法和特色如下。按作业办法分有循环作业式和连续作业式两种。循环作业式的供料、搅拌、卸料三道工序是按必定的时间距离周期进行的，即按份拌制。

The purpose of cement concrete mixer is to mix cement concrete mechanically. There are many kinds. The classification methods and characteristics are as follows. According to the operation method, there are two types: circular operation type and continuous operation type. The three processes of circular feeding, mixing and unloading are carried out periodically according to a certain time distance, that is, mixing by parts.

由于拌制的各种物料都经过准确的称量，故搅拌质量好。现在大多选用此种类型的作业办法。连续作业式的上述三道工序是在一个较长的筒体内连续进行的。尽管其生产率较循环作业式高，但由于各料的合作比、搅拌时间难以控制，故搅拌质量差。现在运用较少。

Because all kinds of materials are accurately weighed, the mixing quality is good. At present, this type of operation method is mostly used. The above three processes of continuous operation are carried out continuously in a long cylinder. Although its productivity is higher than that of circular operation, the mixing quality is poor because the cooperation ratio and mixing time of each material are difficult to control. It is less used now.

按搅拌办法分有自落式搅拌、强制式搅拌两种。自落式搅拌机就是把混合料放在一个旋转的搅拌鼓内，跟着搅拌鼓的旋转，鼓内的叶片把混合料提升到必定的高度，然后靠自重自在撒落下来。这样周而复始地进行，直拌匀中止。这种搅拌机一般拌制塑性和半塑性混凝土。

According to the mixing method, there are two kinds: self falling mixing and forced mixing. The self falling mixer is to put the mixture in a rotating mixing drum. With the rotation of the mixing drum, the blades in the drum lift the mixture to a certain height, and then drop it freely by self weight. This is repeated until the mixing stops. This mixer generally mixes plastic and semi-plastic concrete.

强制式搅拌机是搅拌鼓不动，而由鼓内旋转轴上均置的叶片强制搅拌。这种搅拌机拌制质量好，生产效率高；但动力消耗大，且叶片磨损快。一般适用于拌制干硬性混凝土。

The forced mixer is that the mixing drum does not move, and the forced mixing is carried out by the blades arranged on the rotating shaft in the drum. The mixer has good mixing quality and high production efficiency; However, the power consumption is large and the blade wear is fast. It is generally suitable for mixing dry and hard concrete.