凝土搅拌机在使用前应按照使用说明书的要求，对各系统和部件逐项进行检验及必要的试运转。空车运转，检查搅拌筒或搅拌叶的转动方向，各工作装置的操作、制动，确认正常，方可作业。此外还有更多事项要了解到，如下：

Before using the concrete mixer, each system and component shall be inspected item by item and necessary test run shall be carried out according to the requirements of the operation manual. When the truck runs empty, check the rotation direction of the mixing drum or mixing blade, the operation and braking of each working device, and confirm that they are normal before operation. In addition, there are more matters to learn as follows:

固定式混凝土搅拌机，应安装在牢固的台座上。当长期使用时，应埋置地脚螺栓；如短期使用，可在机座下铺设枕木并找平放稳。

Fixed concrete mixer shall be installed on a firm pedestal. When it is used for a long time, the anchor bolt shall be embedded; If it is used for a short time, sleepers can be laid under the base and leveled.

对于移动式混凝土搅拌机，应安装在平坦坚硬的地坪上用方木或撑架架牢，并保持水平面轮胎不受力。

For mobile concrete mixer, it shall be installed on a flat and hard floor and firmly supported with square timber or brackets, and the tire on the horizontal surface shall be free from force.

对某些需要挖设上料斗地坑的搅拌机，其坑口周围应垫高夯实，以防地面水流入坑内。上料轨道架的底端支承面应夯实或铺砖、架的后面亦须用木料加以支承，防止工作时轨道变形。

For some mixers that need to dig a hopper pit, the pit opening shall be padded and compacted to prevent the ground water from flowing into the pit. The bottom bearing surface of the loading track frame shall be tamped or paved with bricks. The back of the frame shall also be supported with wood to prevent the track from deformation during operation.

混凝土搅拌机启动后，应使搅拌筒达到正常转速后进行上料，上料后要及时加水；添加新料须先将搅拌机内原有的混凝土全部卸出后才能进行。不得中途停机或满载荷时起动搅拌机，反转出料者除外。

After the concrete mixer is started, the mixing drum shall be fed when it reaches the normal speed, and water shall be added in time after feeding; Add new materials only after all the original concrete in the mixer is discharged. It is not allowed to stop the mixer midway or start the mixer when it is fully loaded, except for reverse discharging.

在混凝土搅拌机使用中，切勿使砂石落入机器运转部分中去，以免使运转部件卡住损坏。上料斗提升后，斗下不能有人通过或停留，以免制动器失灵发生意外事故。

During the use of the concrete mixer, do not let the sand and gravel fall into the running part of the machine, so as to prevent the running parts from being stuck and damaged. After the loading hopper is lifted, no one can pass or stay under the hopper to avoid accidents due to brake failure.

作业中，如发现故障不能继续运转时，应立即切断电源，将搅拌筒内的混凝土干净，然后进行检修。

During the operation, if any fault is found and the operation cannot continue, the power supply shall be cut off immediately, the concrete in the mixing drum shall be cleaned, and then maintenance shall be carried out.

作业后，应对搅拌机进行面清洗，操作人员如需要进入筒内清洗时，须切断电源，设专人在外监护，或卸去熔断器并锁好电闸箱，然后方可进入。

After operation, the surface of the mixer shall be cleaned. If the operator needs to enter the cylinder for cleaning, he/she must cut off the power supply, assign a special person to monitor outside, or remove the fuse and lock the switch box before entering.

上料斗的摇把，应用销子固定，以免人进入简内清理时，身体碰触摇把使料斗提升，发生挤压事故。

The handle of the feeding hopper shall be fixed with a pin to prevent the hopper from being lifted due to body contact with the handle when a person enters the cabin for cleaning, which may lead to an extrusion accident.

不同类型混凝土搅拌机都要进行正确使用的相关事项就讲解到这里了，您对此有什么想法或者疑惑或者需求，可以随时来我们网站http://www.zkhntjbc.com进行咨询！

This is the end of the relevant matters for the correct use of different types of concrete mixers. If you have any ideas or doubts or needs, you can come to our website at any time http://www.zkhntjbc.com Consult!