小型搅拌机其实也是比较脆弱的，所以我们平时一定要细心保养，才能使用得更长久，下面就教你几个小技巧。

Small mixers are actually fragile, so we must maintain them carefully in order to use them for a long time. Here are some tips.

做好换季保健工作，要用冬油脂。搅拌机的发动机、变速器、差速箱、转向机构冬季更换专用润滑油(发动机油位不超过正常范围，也不低于低限度)；搅拌机的轮毂轴承等用低凝点润滑脂代替；柴油车应提前更换冬季适时的柴油，防止恶劣天气下柴油冻冰。

Do a good job in the health care work in the new season, and the key is to use winter oil. The engine, transmission, differential case and steering mechanism of the mixer shall be replaced with special lubricating oil in winter (the oil level of the engine shall not exceed the normal range nor lower than the low limit); The hub bearing of the mixer is replaced with low freezing point grease; Diesel vehicles shall be replaced with timely diesel in winter in advance to prevent diesel from freezing in bad weather.

检查搅拌车电瓶的液位和浓度。冬季要注意保暖和充电，电解液要保持一定的比重和充足的电状态，及时补充电解液或更换电瓶。对保险丝盒进行清洗、检查，及时更换有隐患的保险丝，保持保险丝清洁，避免冬季天黑时因保险丝出问题车辆抛锚。

Check the liquid level and concentration of the battery of the mixer truck. Pay attention to keep warm and charge in winter. The electrolyte should keep a certain proportion and sufficient electric state. Replenish the electrolyte or replace the battery in time. Clean and inspect the fuse box, timely replace the fuse with hidden dangers, keep the fuse clean, and avoid the vehicle from breaking down due to fuse problems in winter.

检查、更换搅拌车的火花塞。冬天点火容易出现问题，温度低，点火能量低，多极火花塞好更换，价格不贵，点火好，能量高。冬天更换搅拌车雨刮片和玻璃水。在玻璃水中加入适当比例的酒精，既能减少冰点，又能防止结冰，是简便的方法。

Check and replace the spark plug of the mixer truck. Ignition in winter is prone to problems. The temperature is low, the ignition energy is low, the multipole spark plug is easy to replace, the price is not expensive, the ignition is good, and the energy is high. Replace the wiper blade and glass water of the mixer in winter. Adding appropriate proportion of alcohol to glass water can not only reduce the freezing point but also prevent freezing. It is a simple method.

检查搅拌机离合器的自由移动行程。经常踩踏离合器，经夏季长时间使用，应调整适当的自由行程，使冬季路滑离合更加精确；搅拌车制动液应保持在正常范围内，调整手刹松紧度，四轮定位，检查制动系统，保持四轮制动基本一致，防止搅拌车制动液跑偏。

Check the free movement stroke of the mixer clutch. If the clutch is frequently pressed and used for a long time in summer, the appropriate free travel should be adjusted to make the road slip clutch more accurate in winter; The brake fluid of the mixer truck shall be kept within the normal range. Adjust the hand brake tightness, four-wheel positioning, check the brake system, keep the four-wheel brake basically consistent, and prevent the brake fluid of the mixer truck from running off.

勤查搅拌车轮胎及气压值。冬天路面摩擦系数低，搅拌车轮胎气压不能过高或过低(外温低，轮胎脆，气压低，柔胎状态会加速轮胎老化)，为确保减少磨损，定期更换轮胎；磨损严重、老化的轮胎应及时更新。

Frequently check the tire and air pressure of the mixer. In winter, the friction coefficient of the road surface is low, and the tire pressure of the mixer shall not be too high or too low (the outer temperature is low, the tire is brittle, the air pressure is low, and the soft tire state will accelerate the aging of the tire). In order to ensure safety and reduce wear, the tire shall be replaced regularly; The tires with severe wear and aging shall be updated in time.

更换油滤嘴，目的在于减少机件内部杂质、水分(冬季较易附着在机件上)对油路的影响；检查、清洗、更换搅拌车空气滤清器滤芯，以减少搅拌车发动机吸气阻力，增加混合气入口，降低油耗，提高功率。更多注意事项就来关注我们网站http://www.zkhntjbc.com！

The purpose of replacing the oil filter is to reduce the influence of impurities and moisture inside the parts (it is easy to attach to the parts in winter) on the oil path; Check, clean and replace the air filter element of the mixer truck to reduce the suction resistance of the mixer truck engine, increase the inlet of the mixed gas, reduce the fuel consumption and improve the power. For more notes, please follow our website http://www.zkhntjbc.com ！