很多人都把自动混凝土搅拌机看成赚钱的工具，只知道使用，却忽略了出车前的正确准备事项，很大可能会在某出现故障危及，下面来讲讲相关事项。

Many people regard the automatic concrete mixer as a tool to make money. They only know how to use it, but they ignore the correct preparations before driving. It is likely that some day there will be a failure endangering the safety. Let's talk about the relevant matters below.

检查、发现问题排除故障

Check, find problems and troubleshoot

搅拌车害怕在路上罐子不转，混凝土一般停罐不能超过2个小时，C40以上级别的混凝土在路上罐子就不能停。车子启动后，先让罐子低速旋转，围绕着车检查轮胎气压，看是否有漏气的胎，检查是否有石子、铁钉之类扎在胎里，及时清理干净。检查侧灯务必保证照着轮胎边缘，因为工地会经常乱堆放钢筋之类杂物，而胎侧是薄弱的。

The mixer truck is afraid that the tank will not turn on the road. Generally, the concrete can not be stopped for more than 2 hours, and the concrete above C40 can not be stopped on the road. After the car starts, let the tank rotate at a low speed. Check the tire pressure around the car to see if there is a flat tire. Check if there are stones, nails, etc. stuck in the tire. Clean it up in time. When checking the side lamp, make sure to shine on the edge of the tire, because the construction site will often pile up reinforcement and other sundries, and the tire side is weak.

保证水箱里有足够的水，有减水剂

Ensure that there is enough water and water reducer in the water tank

因各种原因料太干，没有水添加放不出料的时候，减水剂就是救命稻草了，可以保证混凝土的流动性。

The material is too dry for various reasons. When there is no water to add and the material cannot be discharged, the water reducer is a lifesaving straw, which can ensure the fluidity of concrete.

确认搅拌罐处于停止状态

Confirm that the mixing tank is stopped

因为发动机启动时万一罐子处于高速旋转状态，瞬间的力会很大的，伤减速机和泵马达系统。

If the tank rotates at a high speed when the engine starts, the instantaneous force will be great, which will damage the reducer and pump motor system.

检查特别注意事项

Special precautions for inspection

减速机齿轮油，液压系统（马达、油泵、散热器）的油初次工作100小时更换，以后每1000小时更换（每年少更换1次）。散热器、传动轴、滚道、拖轮、主槽转轴、操纵杆每月加注一次黄油。

The gear oil of the reducer and the oil of the hydraulic system (motor, oil pump, radiator) shall be replaced after 100 hours of operation for the first time, and then every 1000 hours (at least once a year). Grease the radiator, transmission shaft, raceway, tugboat, main slot shaft and control lever once a month.

自动混凝土搅拌机出车前就是要知道以上所讲解的内容，这只是事项的一部分，更多更为详细的操作您可以随时来我们网站http://www.zkhntjbc.com联系做对接。

Before the automatic concrete mixer is delivered, you should know what is explained above. This is just a part of the matter. For more detailed operations, you can come to our website at any time http://www.zkhntjbc.com Contact for docking.